Product ID:PREPRITE LATEX INTERIOR/EXTERIOR BLOCK FILLER, B25 W 25
MSDS Date:03/10/1998
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CLCKV

THE SHERWIN-WILLIAMS CO.

101 PROSPECT AVE. N.W.
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 1NE25

SHERWIN-WILLIAMS CO THE

HONOLULU, HI 96817 US

Telephone: 808-842-4000, FAX 808-842-0818

Cage: 1M7C1

KAOLIN

CAS: 1332-58-7

RTECS: GF1670500

OSHA PEL 5 MG/M3 (RESP. DUST)

ACGIH TLV: 2 MG/M3 (RESP. DUST)

CALCIUM CARBONATE

CAS: 471-34-1

RTECS: FF9335000

OSHA PEL 15 MG/M3 (AS DUST)

ACGIH TLV: 10 MG/M3 (AS DUST

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 10 MG/M3 (AS DUST)

ACGIH TLV: 10 MG/M3 (AS DUST)

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ROUTES OF EXPOSURE: EXPOSURE MAY BE BY
INHALATION AND/OR SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF
USE. TO MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION , AND PERSONAL PR OTECTIVE EQUIPMENT. ACUTE HEALTH
HAZARDS: EFFECTS OF OVEREXPOSURE: IRRITATION OF EYES, SKIN AND
UPPER RESPIRATORY SYSTEM. IN A CONFINED AREA VAPORS IN HIGH
CONCENTRATION MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS. CHRONIC
HEALTH HAZARDS: PROLONGED OVEREXPOSURE TO SOLVENT INGREDIENTS IN
(INGREDIENTS) SECTION MAY CAUSE ADVERSE EFFECTS TO THE LIVER AND
URINARY SYSTEMS.
Explanation of Carcinogenicity:N/A.
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. IF IN
EYES: FLUSH EY ES WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES. GET
MEDICAL ATTENTION. IF SWALLOWED: GET MEDICAL ATTENTION.

Flash Point:NONE.
Lower Limits:N.AP.
Upper Limits:N.AP.
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIP INCL (NIOSH APPROVED - )
SELF-CONTAINED BREATHING APPARAUTS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP
& POSS AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: NOT APPLICABLE.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:DOL STORAGE CATEGORY-NOT APPLICABLE.
KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO NOT TAKE
INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN.
Other Precautions:PRECAUTIONS TO BE TAKEN IN USE: USE ONLY WITH
ADEQUATE VENTILATION. AVOID BREATHING VAPOR AND SPRAY MIST. AVOID
CONTACT WITH SKIN AND EYES. WASH HANDS AFTER USING.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN (ING REDIENTS) SECTION. WHEN SANDING,
WIREBRUSHING, ABRADING, BURNING OR WELDING THE DRIED FILM, WEAR A
PARTICULATE RESPIRATOR APPROVED BY (WORK HYGENIC PRACTICES)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIAL IN (INGREDIENTS) SECTION IS MAINTAINED BELOW
APPLICABLE (OTHER PROT EQUIP)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL SAFETY GOGGLES .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FN N). VENTILATION (CONT): EXPOSURE LIMITS.
REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH HANDS AFTER USING. RESPIRATORY PROTECTION (CONT): NIOSH
FOR PROTECTION AGAINST NON-VOLATILE MATERIALS IN (INGREDIENT)
SECTION.
Supplemental Safety and Health
THESE COATINGS MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED "AS DUST" IN INGREDIENTS SECTION ) WHICH MAY
BE PRESENT AT HAZARDOUS LEVELS ONLY DURING SANDING OR ABRADING OF
THE DRIE D FILM. IF NO SPECIFIC DUSTS ARE LISTED IN THE INGREDIENTS
SECTION, THE APPLICABLE LIMITS FOR NUISANCE (OTHER INFO)

Boiling Pt:=100.C, 212.F
B.P. Text:212 - 477F.
Melt/Freeze Pt:M.P/F.P Text:N.A. (MELTING)
Vapor Density:> THAN AIR
Spec Gravity:1.24 - 1.64.
pH:9.0 - 10.0
VOC Grams/Liter:.24
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:N.A.
Appearance and Odor:NOT SPECIFIED BY MANUFACTURER .
Percent Volatiles by Volume:49 - 76%

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS SECTION.

Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA)
40CFR261. INCINERATE ALL PRODUCTS IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.

Toxicological Information:CRYSTALLINE SILICA (QUARTZ, CRISTOBALITE) IS
LISTED BY IARC AND NTP. LONG TERM EXPOSURE TO HIGH LEVELS OF SILICA
DUST, WHICH CAN ONLY OCCUR WHEN SANDING OR ABRADING THE DRY FILM,
MAY CAUSE LUNG DAMAGE (SILICOSIS) AND POSSIBLY CANCER. ETHYLENE
GLUCOL IS CONSIDERED AN ANIMAL TERATOGEN. IT HAS BEEN SHOWN TO
CAUSE BIRTH DEFECTS IN RATS AND MICE AT HIGH DOSES WHEN GIVEN IN
DRINKING WATER OR BY LAVAGE. THERE IS NO EVIDENCE TO INDICATE IT
CAUSES BIRTH DEFECTS IN HUMANS. RATS EXPOSED TO TITANIUM DIOXIDE
DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOSURE
LEVELS ARE NOT ATTAINABLE IN THE WO RKPLACE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Federal Regulatory Information:TSCA: ALL CHEMICALS IN THESE PRODUCTS
ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: B28 3
300 CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. B25 W 25, B28 W 101, B28 W 200, B28 W 400, B28 W 601, B51 W
20 AND B51 W 50 CONTAIN CHEMICALS KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER.